Magazine article Consumers' Research Magazine

Sport Utility Bumpers: Damage Repair Costs

Magazine article Consumers' Research Magazine

Sport Utility Bumpers: Damage Repair Costs

Article excerpt

Some automakers are improving the bumpers on their cars so consumers are less likely to face expensive repairs from low-speed collisions, but these improvements aren't carrying over to utility vehicles. They still have bumpers that typically allow expensive damage in low-speed crashes.

The Insurance Institute for Highway Safety recently tested six 1999 model midsize utility vehicles, only two of which allowed less than $5,000 damage in four impacts at five mph. The worst vehicle tested, Mitsubishi's Montero Sport, sustained more than $6,000 damage. "There was a wide range of damage, with a couple of utility vehicles doing better than the others," Institute senior vice president Adrian Lund points out. "But even the best one we tested, the Mercedes ML 320, sustained about $3,000 damage."

Four other 1999 midsize utility vehicles--Lexus RX 300, Jeep Grand Cherokee, Land Rover Discovery, and Dodge Durango--performed better than the Montero Sport but far from well (see table). "This is very different from the rugged image utility vehicle manufacturers are selling. Instead of rugged, a more appropriate description for the bumpers on these vehicles is flimsy," Lund says.

Little Improvement from Previous Tests of Same Vehicles. The Institute previously tested 1996 models of the Jeep Grand Cherokee and Land Rover Discovery. In both cases, the bumper performances were poor. This time around, the vehicles have been redesigned, giving the automakers a chance to see what went wrong in the previous tests and equip the new models with bumpers that do a better job of resisting damage in five mph impacts. There were improvements, but they weren't impressive (see table). Both vehicles performed somewhat better but still racked up more than $5,000 damage in the four low-speed impacts.

To assess bumper performance, the Institute conducts a series of four crash tests at five mph--front and rear flat-barrier impacts plus two localized impacts, front-into-angle-barrier and rear-into-pole.

Two Pole Tests of Dodge Durango. When the rear of this utility vehicle hit the pole at five mph, the minor impact activated the door latch and the tailgate opened. The automaker made changes in the rear bumper system and asked for another pole test. The result was that, the second time, the latch didn't open and the vehicle sustained about $500 less damage in the impact. However, there still was more than $1,000 damage in the pole test alone.

No Damage-Resistance Requirements. One reason the utility vehicles performed so poorly is that they aren't subject to any requirements to prevent damage in low-speed impacts. Car bumpers have to meet federal standards in 2.5 mph impacts, and most of the bumpers on cars include a reinforced bumper bar and foam or other material to absorb crash energy. But the bumpers on many utility vehicles don't. The Montero Sport's bumper system, for example, doesn't include energy-absorbing material, and the bumper bar "isn't much of a bar at all," Lund notes. "It's just a thin steel plate that functions more to support the bumper cover than to resist damage in low-speed impacts."

Another problem is that the bumper parts themselves are very expensive, which drives up the cost of repairs. For example, the front bumper on the Discovery is a one-piece system. Extensive damage to any part of it means the whole thing has to be replaced at a cost of $600 for the part alone. This is one reason repair costs were so high for this vehicle after the two frontal impacts at five mph.

Damage Repair Costs In Five-mph Crash Tests

1999 Midsize Sport                  Front      Rear        Front
Utility Vehicles                     Into      Into   Into Angle

                                  Barrier   Barrier      Barrier

Mercedes ML 320                     $346      $121         $951
Lexus RX 300                        $422      $334       $1,418
Jeep Grand Cherokee
  1999 model                        $641      $871       $1,578
  1996 model                        $758    $1,677       $2,025
Land Rover Discovery
  1999 model                        $914    $1,238       $2,275
  1996 model                        $745    $2,298       $2,879
Dodge Durango                     $1,494      $702       $1,716
(2nd test after bumper changes)
Mitsubishi Montero Sport          $1,141    $1,239       $2,122

1999 Midsize Sport                  Rear
Utility Vehicles                    Into     Total
                                    Pole    Damage

Mercedes ML 320                   $1,500    $2,918
Lexus RX 300                      $1,119    $3,293
Jeep Grand Cherokee
  1999 model                      $2,017    $5,107
  1996 model                      $1,945    $6,405
Land Rover Discovery
  1999 model                       $799     $5,226
  1996 model                      $1,287    $7,209
Dodge Durango                     $1,743    $5,655
(2nd test after bumper changes)   $1,241    $5,153
Mitsubishi Montero Sport          $1,780    $6,282

Note: Repair costs reflect January 1999 prices. …

Search by... Author
Show... All Results Primary Sources Peer-reviewed

Oops!

An unknown error has occurred. Please click the button below to reload the page. If the problem persists, please try again in a little while.