Newspaper article The Canadian Press

Super Beam to Be Installed to Support Crumbling Girder on Key Montreal Bridge

Newspaper article The Canadian Press

Super Beam to Be Installed to Support Crumbling Girder on Key Montreal Bridge

Article excerpt

Crumbling Montreal bridge gets super beam

--

MONTREAL - The continuing deterioration of a supporting beam in one of Canada's busiest bridges has prompted major unexpected repairs.

Montreal's Champlain Bridge may even be closed to traffic if there are any doubts about its safety and security.

Glen Carlin, the general manager of the corporation which oversees Montreal's federally-run bridges, said the cracked beam is being inspected twice daily.

He insisted the corporation will take whatever measures are needed to ensure the safety of the structure.

"If we have to close three lanes, we will close three lanes," he said. "If we have to close the bridge, we will close the bridge."

In the short term, a steel "super" beam will be used to support a girder in the middle of the bridge after a two-millimetre crack widened.

The crack was discovered last week and other fissures have also been found in the beam since then.

The cracked girder is one of seven under the span which support the six lanes of the bridge.

Carlin said the other six girders are still in good condition, but he admitted to reporters Friday that the problem beam deteriorated faster than expected.

"We did not anticipate that this beam would continue to present structural cracks," he said.

"Last Friday, our repair method was completely different. We said, 'OK, it's under control and we have a minor crack which doesn't seem to be developing'.

"We did not expect to see the beam have signs of distress show up so quickly."

Carlin said the 75-tonne super beam, which was delivered in 2009, will be installed by mid-December. The three-metre-high beam, which cost $350,000, will be placed on top of the deteriorating girder.

Next spring, it is to be replaced with a modular truss which will be installed underneath the problem beam.

Carlin has previously estimated that 350 beams on the bridge are in different states of deterioration.

In the meantime, truck traffic will be restricted and speed will be reduced for all vehicles that use the bridge. …

Search by... Author
Show... All Results Primary Sources Peer-reviewed

Oops!

An unknown error has occurred. Please click the button below to reload the page. If the problem persists, please try again in a little while.